320:
most other components of the vehicle and modern spark plugs have excellent service life, though there is a slight-difference between the two plugs as to erosion suffered at the center electrode. Because the spark jumps in opposite directions on the companion plugs, one bank will erode the center electrode more, and the opposite bank will erode the ground electrode more. Spark plugs used in wasted spark systems should have precious metals, such as platinum and/or iridium, on both the central and ground electrodes in order to increase the average service interval time before replacement is needed.
178:
crankshaft can be used instead, as the system fires on both upward strokes. It simplifies the mechanical arrangements since there is no distributor drive and the contact breaker cam can be fixed to the crankshaft. Although a 2:1 reduction gear is still required to operate the camshaft and valves, the precision of this drive is now less critical (ignition timing is more critical for engine performance than valve timing): engines continue to run adequately even with worn camshaft drives and imprecise timing.
187:
25:
122:
152:
extra spark, against much reduced dielectric resistance, barely impacts the lifespan of modern ignition components. In a typical engine, it requires only about 2–3 kV to fire the cylinder on its exhaust stroke. The remaining coil energy is available to fire the spark plug in the cylinder on its compression stroke (typically about 8 to 12 kV).
319:
In modern conditions, this method has a very small impact on the length on the service intervals of the vehicle and the longevity of individual components. Modern ignition systems do not have breaker points, which have been almost entirely replaced by electronic systems. Modern ignition coils outlast
279:
In practical use, a V-6 engine would only need three coil packs instead of six. The coilpack fires the spark plugs in two cylinders simultaneously so for example 1&4/2&5/3&6 cylinders fire together, the spark plug in one cylinder on a compression stroke is where the power comes from, and
177:
Wasted spark systems still require a timing signal from the crankshaft. In a conventional four-stroke engine, this signal must also observe the phase of the camshaft relative to the crankshaft, so contact breakers are normally driven from the camshaft and distributor drive. With a wasted spark, the
288:
Most single cylinder engines use the wasted spark system in order to capitalise on the simplicity and reliability of the flywheel magneto. These engines need a flywheel to run smoothly, and the heavy current-generating magnets help provide the momentum while delivering a zero-maintenance drive to
151:
fire in pairs, with one plug in a cylinder on its compression stroke and the other plug in a cylinder on its exhaust stroke. The extra spark during the exhaust stroke has no effect and is thus "wasted". This design halves the number of components necessary in a typical ignition system, while the
332:
have been used, with two spark plugs for each cylinder. Each set of plugs is supplied separately. Reasons for this include reliability (especially as a failsafe in aircraft engines), for improved starting, and for better combustion performance by initiating the flamefront at opposing points
168:
systems would later offer this same advantage, they were not available for another 30 years. Plug-top systems increase the number of coils required, increase the heat that these coils must survive and thus require more sophisticated and expensive materials to survive routine usage.
280:
the spark plug in the other cylinder on an exhaust stroke does nothing. Coils in a wasted spark system may be in pack form, or they may be in Coil-On-Plug (COP) form, with a spark plug cable attached to each COP unit, which connects to another spark plug.
164:. This significantly improves reliability, since many problems with a conventional system are caused by the distributor being affected by dampness from rain or condensation, dirt accumulation, and degradation of insulating materials with time. Although
337:). These are not considered as wasted spark systems since their sparks all take place after the useful compression stroke rather than "wasted" in the exhaust stroke.
276:
engines also follow a similar design, to allow for a smaller number of more powerful coils to replace a larger number of smaller coils in the same limited space.
296:
that spark generation would otherwise place on the camshaft chain (or another special purpose half-speed drive) is avoided, while there is virtually none of the
292:
As well as the build-weight and maintenance advantages of this system, there is a tuning advantage. Mounted directly on the end of the crankshaft, all the
307:
lead running to the single plug. The flywheel magneto provides other services in, for instance, small motorcycles, as it can easily be built to provide
303:
Unlike the multi-cylinder systems noted above (which fire two plugs simultaneously from a double-ended coil) the coil in this system has only a single
160:
Perhaps the most significant advantage of the system, compared to a single coil and distributor systems, is that it eliminates the high-tension
380:
89:
61:
364:
68:
42:
257:
108:
75:
289:
the ignition system. Bolted to the end of the crankshaft, this flywheel rotates twice for each compression stroke.
269:
57:
46:
334:
195:
297:
144:
198:
233:
82:
35:
387:
354:
261:
421:
273:
8:
241:
209:
293:
245:
360:
300:
that necessarily degrades the ignition timing in systems relying on chains or gears.
141:
253:
194:
This system has been widely used, including such engines as the MG MG6 1.8T engine;
249:
221:
213:
137:
308:
229:
186:
225:
126:
415:
329:
206:
165:
304:
16:
Ignition system used in some four-stroke cycle internal combustion engines
161:
404:
237:
148:
24:
202:
311:
battery-charging power at almost no additional cost or weight.
217:
121:
356:
Automotive
Diagnostic Systems: Understanding OBD I and OBD II
265:
381:"2CV wiring diagram and distributorless double-ended coil"
181:
49:. Unsourced material may be challenged and removed.
403:See p. 824 of the 2015 Champion Master Catalog.
413:
314:
109:Learn how and when to remove this message
185:
120:
323:
414:
352:
283:
405:http://www.fme-cat.com/catalogs.aspx
328:Since the earliest gasoline engines
182:Practical examples of 'wasted spark'
47:adding citations to reliable sources
18:
393:on 2016-03-03 – via 2cvstuff.
258:Chrysler 1.8, 2.0 & 2.4 engines
13:
14:
433:
147:. In a wasted spark system, the
212:(M104.94x, M104.98x, M104.99x);
190:Ignition Coils of a Ford RS1600i
172:
23:
125:Ignition system of a flat-twin
34:needs additional citations for
397:
373:
346:
1:
340:
155:
7:
145:internal combustion engines
10:
438:
244:2.8 VR6 (other than 2.0);
216:engines (LN3 and newer);
315:Effect on component life
353:McCord, Keith (2011).
264:engines also do. Many
218:Harley-Davidson V-Twin
191:
129:
333:simultaneously (e.g.
189:
124:
58:"Wasted spark system"
324:Twin plug combustion
196:Mitsubishi Evolution
43:improve this article
284:Single cylinder use
242:Volkswagen Golf Mk3
134:wasted spark system
330:twin spark systems
246:Saturn Corporation
192:
130:
366:978-1-934709-06-1
142:four-stroke cycle
119:
118:
111:
93:
429:
407:
401:
395:
394:
392:
386:. Archived from
385:
377:
371:
370:
350:
248:four cylinders;
114:
107:
103:
100:
94:
92:
51:
27:
19:
437:
436:
432:
431:
430:
428:
427:
426:
412:
411:
410:
402:
398:
390:
383:
379:
378:
374:
367:
359:. CarTech Inc.
351:
347:
343:
326:
317:
286:
272:motorcycle and
230:Mazda B engines
222:BMW Motorcycles
203:Fiat 126 engine
184:
175:
158:
138:ignition system
115:
104:
98:
95:
52:
50:
40:
28:
17:
12:
11:
5:
435:
425:
424:
409:
408:
396:
372:
365:
344:
342:
339:
325:
322:
316:
313:
309:direct-current
285:
282:
183:
180:
174:
171:
157:
154:
117:
116:
31:
29:
22:
15:
9:
6:
4:
3:
2:
434:
423:
420:
419:
417:
406:
400:
389:
382:
376:
368:
362:
358:
357:
349:
345:
338:
336:
331:
321:
312:
310:
306:
301:
299:
295:
290:
281:
277:
275:
271:
267:
263:
259:
255:
251:
250:Toyota 5VZ-FE
247:
243:
239:
235:
234:Chrysler V10s
231:
227:
223:
220:; air-cooled
219:
215:
211:
208:
207:Mercedes-Benz
204:
200:
197:
188:
179:
173:Timing signal
170:
167:
166:plug-top coil
163:
153:
150:
146:
143:
140:used in some
139:
136:is a type of
135:
128:
123:
113:
110:
102:
99:February 2017
91:
88:
84:
81:
77:
74:
70:
67:
63:
60: –
59:
55:
54:Find sources:
48:
44:
38:
37:
32:This article
30:
26:
21:
20:
399:
388:the original
375:
355:
348:
327:
318:
302:
291:
287:
278:
254:Toyota 5E-FE
210:inline sixes
193:
176:
159:
133:
131:
105:
96:
86:
79:
72:
65:
53:
41:Please help
36:verification
33:
422:Spark plugs
226:Citroën 2CV
199:4G63 engine
162:distributor
149:spark plugs
127:Citroën 2CV
341:References
335:Alfa Romeo
238:GY6 engine
214:Buick 3800
156:Advantages
69:newspapers
416:Category
270:Kawasaki
260:. Some
83:scholar
363:
298:strain
294:stress
85:
78:
71:
64:
56:
391:(PDF)
384:(PDF)
266:Honda
252:V6s;
90:JSTOR
76:books
361:ISBN
268:and
262:Ford
256:and
62:news
274:PWC
45:by
418::
305:HT
240:;
236:;
232:;
228:,
224:;
205:,
201:,
132:A
369:.
112:)
106:(
101:)
97:(
87:·
80:·
73:·
66:·
39:.
Text is available under the Creative Commons Attribution-ShareAlike License. Additional terms may apply.
