516:
Q-Jets. They were also equipped with a self-contained choke mechanism that no longer relied on an intake manifold mounted choke, and a number "1" was added to the beginning of their identification numbers. The digits in a
Quadrajet model type denote its features. For example, the "E" at the end of a later Q-jet model denoted that it had an electric choke, the "C" denoted a hot air coil style choke element. Original Delco service kits were once sold through both GM dealers and Delco distributors and were called "Power Kits". These have long been discontinued, although there are several aftermarket sources that still supply parts for these carburetors.
308:, allowing the mixture to be lean under low load conditions and rich during high load conditions. A less-common version uses a linkage driven off the primary throttle shaft to mechanically move the power piston. "E" (electronic control module controlled) series of Quadrajets use a computer controlled mixture control solenoid that responds to electronic signals from the throttle position and oxygen sensors via the computer, ideal for precise fuel metering and allowing additional fuel under load. The solenoid-controlled metering rods allow the fuel mixture to be very close to optimum, then the solenoid is
317:
As the airflow increases through the secondary bores, the air valves are pushed down, rotating a cam that lifts the secondary metering rods. The secondary rods are tapered in a similar fashion to the primary metering rods, effectively increasing the size of the fuel metering holes as the rods are lifted and delivering more fuel. Therefore, the position of the air valve will control both fuel and air flow through the secondary venturis, even if the secondary throttle plates are fully opened. Thus, the
Quadrajet acts like a vacuum-secondary carburetor and only delivers more fuel as it is needed.
342:
resulted in hot start difficulties because of flooded engines. Production of the DOVE, which was underway in 1963 when the hot start problem was identified, was suspended and a crash project was initiated to fix the problem. Simultaneously a second crash project was initiated to develop a modified DOVE which became the
Quadrajet. Prototype Quadrajet carburetors were in test at Rochester Products by the Fall of 1963. The DOVE hot-start problem was corrected but not in a timely enough manner; the production DOVEs were destroyed and the Quadrajet took its place.
525:
temperature. Later models, second generation
Quadrajets, (1974-onward), were designed with a self-contained choke housing that held the heat sensitive spring and directly operated the choke mechanism. This system relied on hot air drawn from a small heat exchanger in the intake manifold—and later models, (generally 1978-onward), relied on the vehicle's 12 volt system to power a heating element and spring as the engine's temperature increased.
356:
63:
165:
22:
453:
532:. This was due to the fact that Rochester could not keep up with the demand for carburetors at various points in their production. Carter-built Quadrajets will have the name "Carter" cast into them, but are functionally identical to the Rochester-built equivalent. The "newest" Q-Jets were built for, and sold by
304:) maximum, but some rare Buick and Pontiac models were capable of 800 cu ft (23,000 L)/min for use on high performance engines, and most 1984-1987 pickup trucks were also equipped with the 800-cfm carb. Most Quadrajets use a vacuum operated piston to move the primary metering rods to control the
505:
The carburetors have been billed as difficult to tune and unreliable by some, however, many times this is simply attributed to the lack of knowledge of the unit itself. Consequently, many
Quadrajets were replaced with other brands of carburetors in an often ill-fated attempt to rectify a problem that
536:. There were several versions made, for both stock replacement and "performance" applications. One version was specifically intended as a replacement for Carter ThermoQuad carburetors. The Edelbrock Q-jets have been discontinued, although at this time Edelbrock still supplies some replacement parts.
524:
The choke provision for the
Quadrajet was initially in the form of an intake-mounted, heat sensitive spring, (divorced choke), often referred to as a heat riser. The spring connected to a rod that actuated the choke mechanism on the passenger's side of the carburetor, and relied on intake manifold's
472:
The very small float bowl/fuel chamber can result in fuel starvation in extreme high-performance situations, but can usually be traced to a fuel delivery problem to the carburetor, such as a weak fuel pump or a worn/rounded camshaft eccentric that drives the fuel pump lever. The latter situation can
341:
The
Quadrajet carburetor was actually a derivative of a variable venturi carburetor called the DOVE (diaphragm operated variable entrance) which was developed in the 1961-63 time frame at Rochester Products. Testing at the GM test facility in Arizona uncovered a hot engine percolation problem which
329:
Economy. Unlike most other four-barrel carburetors, the
Quadrajet has a drastically different sized primary and secondary bores. The much smaller primaries act as a small two-barrel carburetor until the accelerator is pressed far enough to start to open the secondaries. The small primaries allow the
316:
Quadrajet carburetors have mechanical secondary throttle plates operated by a progressive linkage; the primaries open before the secondaries, and use on-demand air valve plates above the secondary throttle plates. The air valves are connected by a cam and linkage to the secondary fuel metering rods.
493:
Almost all
Quadrajets today have some amount of warpage of the castings although less pronounced in the so-called "mod Quad" versions after 1974 which were a bit heavier and better designed to resist warping. The root cause of this warpage is over-tightening the front two carburetor mounting bolts,
501:
Over much use, the steel primary throttle shaft will tend to wear the aluminum casting material in the throttle body. This results in a minor air leak and in extreme cases, can cause the primary throttle blades to not close properly. This results in poor idle quality. Some carburetor parts vendors
515:
A major change to the
Quadrajet was implemented for the 1975 model year. These newer carburetors are considered "Modified Quadrajets" or "Mod Quads". In addition to the casting revisions that result in a physically larger carburetor, the primary metering rod length is different from '74 and older
464:
Its leaky fuel bowl. As in nearly all carburetors, the Quadrajet's bowl had pressed-in plugs used to seal holes left after drilling fuel passages during the manufacturing of the carburetor. These plugs in the Q-jet sometimes leaked fuel causing difficult cold-engine starting, erratic idling, poor
476:
The fuel inlet/fuel filter housing threads tend to be very fragile. When care is not taken to align the insert, it is possible for the fuel inlet to cross-thread and to strip when tightened in the main housing. There are several "fixes" available in the aftermarket: New, oversized, self-tapping
312:
at about 6 Hz to fine-tune the air fuel ratio under closed loop conditions. The electronic versions have a throttle position sensor that is mounted inside the carburetor body, actuated by the accelerator pump lever.
333:
Drivability. The small primaries also create better throttle response at part throttle application. The Quadrajet had a centrally located float that gave it excellent fuel control form the triple Venturi, boosters.
489:
re-threading kits. In nearly all cases, the carburetor will require dis-assembly and internal cleaning of the aluminum thread residue, especially up to and including the needle and seat, (needle valve), to prevent
299:
are much smaller than the secondary venturis. By comparison, a "square bore" carburetor has primary and secondary venturis of similar size. Most Quadrajets were capable of 750 cu ft (21,000 L)/min
330:
primary throttle plates to be opened wider, and thus making the carburetor more efficient than a large two barrel, or square bore four-barrel.
486:
506:
was not caused by the carburetor. When properly tuned, the Quadrajet is both an efficient and effective performing carburetor.
570:
337:
Off Road. The Quadrajet’s centrally located float is highly resistant to level changes caused by cornering or acceleration.
420:
127:
392:
99:
439:
226:
208:
146:
49:
190:
256:
399:
106:
377:
175:
84:
456:
A Quadrajet M4ME carburetor with electric choke. The Quadrajet went through several changes in its lifetime.
406:
113:
565:
How To Rebuild and Modify Rochester Quadrajet Carburetors; pp 71-72, Cliff Ruggles, CarTech Publications,
248:
373:
80:
35:
388:
95:
593:
366:
186:
73:
502:
offer repair kits for the carburetor body that allow easy repair by installing bronze bushings.
309:
260:
465:
fuel mileage, and excessive emissions. Many Quadrajets have their fuel bowl plugs sealed with
588:
301:
276:
8:
413:
120:
566:
529:
264:
182:
305:
268:
252:
41:
296:
582:
478:
380: in this section. Unsourced material may be challenged and removed.
280:
244:
533:
272:
355:
193:. Statements consisting only of original research should be removed.
62:
482:
495:
466:
284:
452:
295:
The Quadrajet is a "spread bore" carburetor; the primary
528:
Quadrajet carburetors were also built under contract by
494:
often in combination with a base gasket that lacks hard
460:
Significant negative features of the Quadrajet were:
325:
Significant positive features of the Quadrajet were:
255:. Its first application was the new-for-1965 Chevy
87:. Unsourced material may be challenged and removed.
473:be resolved with an external (electric) fuel pump.
580:
481:inserts; new fuel filter inserts that seal with
552:Sherman, U. B. "Quadrajet Quickery II", in
50:Learn how and when to remove these messages
440:Learn how and when to remove this message
227:Learn how and when to remove this message
209:Learn how and when to remove this message
147:Learn how and when to remove this message
451:
259:. Its last application was on the 1990
581:
263:V8 engine, which was last used in the
378:adding citations to reliable sources
349:
158:
85:adding citations to reliable sources
56:
15:
13:
14:
605:
519:
31:This article has multiple issues.
354:
163:
61:
20:
365:needs additional citations for
72:needs additional citations for
39:or discuss these issues on the
559:
546:
469:when rebuilt to prevent leaks.
1:
539:
320:
345:
7:
510:
498:inserts for the bolt holes.
249:Rochester Products Division
189:the claims made and adding
10:
610:
290:
457:
455:
310:pulse width modulated
374:improve this article
81:improve this article
458:
174:possibly contains
571:978-1-932494-18-1
450:
449:
442:
424:
265:Cadillac Brougham
243:is a four barrel
237:
236:
229:
219:
218:
211:
176:original research
157:
156:
149:
131:
54:
601:
573:
563:
557:
550:
445:
438:
434:
431:
425:
423:
382:
358:
350:
232:
225:
214:
207:
203:
200:
194:
191:inline citations
167:
166:
159:
152:
145:
141:
138:
132:
130:
89:
65:
57:
46:
24:
23:
16:
609:
608:
604:
603:
602:
600:
599:
598:
579:
578:
577:
576:
564:
560:
551:
547:
542:
522:
513:
446:
435:
429:
426:
383:
381:
371:
359:
348:
323:
293:
261:Oldsmobile 307
233:
222:
221:
220:
215:
204:
198:
195:
180:
168:
164:
153:
142:
136:
133:
90:
88:
78:
66:
25:
21:
12:
11:
5:
607:
597:
596:
594:General Motors
591:
575:
574:
558:
556:, 12/85, p.50.
544:
543:
541:
538:
521:
520:Choke variants
518:
512:
509:
508:
507:
503:
499:
491:
474:
470:
448:
447:
362:
360:
353:
347:
344:
339:
338:
335:
331:
322:
319:
306:air-fuel ratio
292:
289:
269:station wagons
267:and full size
253:General Motors
247:, made by the
235:
234:
217:
216:
171:
169:
162:
155:
154:
69:
67:
60:
55:
29:
28:
26:
19:
9:
6:
4:
3:
2:
606:
595:
592:
590:
587:
586:
584:
572:
568:
562:
555:
549:
545:
537:
535:
531:
526:
517:
504:
500:
497:
492:
488:
484:
480:
475:
471:
468:
463:
462:
461:
454:
444:
441:
433:
422:
419:
415:
412:
408:
405:
401:
398:
394:
391: –
390:
386:
385:Find sources:
379:
375:
369:
368:
363:This section
361:
357:
352:
351:
343:
336:
332:
328:
327:
326:
318:
314:
311:
307:
303:
298:
288:
286:
282:
278:
274:
270:
266:
262:
258:
254:
250:
246:
242:
231:
228:
213:
210:
202:
192:
188:
184:
178:
177:
172:This article
170:
161:
160:
151:
148:
140:
129:
126:
122:
119:
115:
112:
108:
105:
101:
98: –
97:
93:
92:Find sources:
86:
82:
76:
75:
70:This article
68:
64:
59:
58:
53:
51:
44:
43:
38:
37:
32:
27:
18:
17:
589:Carburettors
561:
554:Popular Cars
553:
548:
527:
523:
514:
459:
436:
427:
417:
410:
403:
396:
384:
372:Please help
367:verification
364:
340:
324:
315:
294:
257:396ci engine
240:
238:
223:
205:
196:
173:
143:
134:
124:
117:
110:
103:
91:
79:Please help
74:verification
71:
47:
40:
34:
33:Please help
30:
479:fuel filter
430:August 2019
389:"Quadrajet"
96:"Quadrajet"
583:Categories
540:References
400:newspapers
321:Advantages
281:Oldsmobile
245:carburetor
199:April 2015
183:improve it
137:April 2015
107:newspapers
36:improve it
534:Edelbrock
490:flooding.
487:Heli-Coil
346:Drawbacks
273:Chevrolet
241:Quadrajet
187:verifying
42:talk page
511:Variants
297:venturis
271:made by
483:O-rings
414:scholar
277:Pontiac
181:Please
121:scholar
569:
530:Carter
485:; and
416:
409:
402:
395:
387:
291:Design
283:, and
123:
116:
109:
102:
94:
496:nylon
467:epoxy
421:JSTOR
407:books
285:Buick
128:JSTOR
114:books
567:ISBN
393:news
239:The
100:news
376:by
302:cfm
251:of
185:by
83:by
585::
287:.
279:,
275:,
45:.
443:)
437:(
432:)
428:(
418:·
411:·
404:·
397:·
370:.
300:(
230:)
224:(
212:)
206:(
201:)
197:(
179:.
150:)
144:(
139:)
135:(
125:·
118:·
111:·
104:·
77:.
52:)
48:(
Text is available under the Creative Commons Attribution-ShareAlike License. Additional terms may apply.